Automatic_Transmission.pdf

(2898 KB) Pobierz
AUTOMATIC
TRANSMISSION .07
.07
818286141.025.png 818286141.026.png 818286141.027.png 818286141.028.png 818286141.001.png 818286141.002.png 818286141.003.png 818286141.004.png 818286141.005.png 818286141.006.png 818286141.007.png 818286141.008.png 818286141.009.png 818286141.010.png 818286141.011.png 818286141.012.png 818286141.013.png 818286141.014.png 818286141.015.png 818286141.016.png
MOPAR PERFORMANCE TERMS AND CONDITIONS
NOTICE
Federal and many state laws prohibit the removal, modiication or rendering inoperative
of any part or element of design affecting emissions or safety on motor vehicles used for
transporting persons or property on a public street or highway. Violation may result in a
ine of up to $32,500 per vehicle. Mechanical and/or electronic performance parts listed
in this catalog with a “1” cannot be used on vehicles used on public streets or highways.
These parts may be used only on vehicles used solely in sanctioned off-highway events. No other applications
are intended or implied. Those parts that have been granted an exemption by the California Air Resources Board
(CARB) or meet the EPA requirements of memorandum 1A are legal for highway use in California, New York, and
Massachusetts and are noted as such.
NO PARTS WARRANTY – “AS IS”
Mopar Performance parts beginning with a “P” preix are sold “as is” unless otherwise noted. This means that
parts sold by Mopar Performance carry no warranty whatsoever. Implied warranties, such as warranties of mer-
chantability, are excluded. (An implied warranty of merchantability means that the part is reasonably it for the
general purpose for which it was sold). The entire risk as to quality and performance of such parts is with the
buyer. Should such parts prove defective following their purchase, the buyer and not the manufacturer, distributor
or retailer, assumes the entire cost of all necessary servicing or repair. Chrysler, Jeep ® , Dodge and Ram vehicle
and parts warranties are voided if the vehicle or parts are used for competition. The addition of performance parts
does not by itself void a vehicle’s warranty. However, added performance parts (parts not originally supplied on
the vehicle from the factory) are not covered by the vehicle’s warranty, and any failure that they may cause is also
not covered by the vehicle’s warranty.
MOPAR PERFORMANCE CRATE ENGINE 90-DAY LIMITED WARRANTY
Mopar Performance Crate Engine Assemblies not used in competition are warranted for “parts only,” AS DELIV-
ERED against defects in materials or workmanship for 90 days from the date of purchase. The following parts, if
defective, will be replaced on an exchange basis for 90 days: engine blocks and all internal parts; cylinder head
assemblies; intake manifold; core plugs; valve covers; oil pan; timing gear; water pump; gaskets and seals. See
your dealer for a copy of the limited warranty, which contains additional terms and limitations.
MOPAR PARTS 12-MONTH LIMITED WARRANTY
Except parts as listed above, certain parts from Mopar Performance sold over the counter or wholesaled are
warranted against defects in workmanship or materials for 12 months/unlimited miles for parts (exchange) only.
These parts are identiied in this catalog as having a speciic part number structure. Part numbers starting with
“P” are not covered under the 12-month warranty. Other parts listed in this catalog without a “P” preix part num-
ber are covered under the 12-Month Limited Warranty described here. See your dealer for a copy of the limited
warranty, which contains additional terms and limitations. Parts installed on a Chrysler, Plymouth, Jeep ® , Dodge
and Ram vehicle by an authorized Chrysler, Jeep ® , Dodge and Ram dealer are warranted for 12 months/unlimited
miles for parts (exchange) only. See your dealer for a copy of the limited warranty, which contains additional terms
and limitations.
818286141.017.png 818286141.018.png 818286141.019.png
EMISSIONS STATEMENT
Federal law requires emissions parts on new vehicles to be warranted for at least two years or 24,000 miles,
whichever comes irst. Federal and many state laws also prohibit the removal, modiication or rendering inop-
erative any part that affects emissions or safety on motor vehicles used on public streets or highways. Many
Mopar Performance parts are designated for track use or off-road use only. Installation of certain components
may bring the vehicle out of compliance with safety and/or emissions standards. Mopar recommends that
vehicles with parts designated in this fashion not be operated on public roads. Mopar Performance customers
are responsible for complying with applicable state and local environmental regulations. Additionally, certain
performance parts may affect the emissions characteristics of the vehicle. If you install them on the vehicle,
and your vehicle consequently fails a required state or local I/M (inspection and maintenance) emissions
test, including any test required to maintain or renew your vehicle’s registration, or if your vehicle is subject
to an emissions recall, Chrysler Group LLC may not be required to repair your vehicle under the emissions
performance warranty, and you may be required to remove those parts at your own expense in order to obtain
repairs necessary to pass the I/M test or to perform the recall.
NOTE — CALIFORNIA ONLY
The emissions laws and regulations of the state of California apply to all non-racing vehicles operated in
California. Consequently, those parts marked in this catalog with a “1” and appropriately marked on their
packaging may legally be used in California only on a racing vehicle that will never be operated on public
roads.
PARTS ORDERING AND INQUIRIES
The parts in this catalog may be ordered from authorized Chrysler, Jeep ® , Dodge and Ram dealerships or the
speed shops carrying the Mopar Performance line of products. When a part ordered has been superseded,
the replacing part will be shipped automatically. The price of the replacing part may differ from the ordered
part. All products, illustrations and speciications are based upon current information at the time of publication
approval. Although descriptions are believed correct, complete accuracy cannot be guaranteed. Chrysler
Group LLC reserves the right to make changes at any time, without notice or obligation, to the information
contained in this printed document, including and without limitation to prices, speciications, equipment,
colors, materials, and to change or discontinue products.
Select images in this catalog are used with permission of Mopar Nationals, Inc., Chrysler Historical Society, and the Walter P. Chrysler Museum.
818286141.020.png
 
TABLE OF CONTENTS
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
54
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
56
ENGINES . . . . . . . . . . . . . . . . . . . . . . . . . . .
10
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
57
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
60
Hemi®, Gen III . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
10
Small Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
64
Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
10
Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
64
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
10
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
66
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
11
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
69
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
12
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
69
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
12
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
70
Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .
12
Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .
71
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
12
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
74
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
13
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
78
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
14
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
82
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
14
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
85
Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
15
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
87
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
15
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
90
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
17
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
93
Transmission and Drivetrain . . . . . . . . . . . . . . . . . . . . . . . .
17
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
95
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
19
Hemi®, Gen II . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
22
RESTORATION . . . . . . . . . . . . . . . . . . . . . .
100
Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
22
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
24
Fuel Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
100
Engine Installation Components . . . . . . . . . . . . . . . . . . . . .
25
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
25
Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
100
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
26
Fuel Pumps and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
101
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
26
Vapor Separator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
102
Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .
27
Six Pack Induction Systems . . . . . . . . . . . . . . . . . . . . . . . . .
102
Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .
27
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
104
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
28
Fuel Injection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
106
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
29
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . .
108
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
30
Distributors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . .
108
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
32
Electronic Ignition Systems . . . . . . . . . . . . . . . . . . . . . . . . .
109
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
34
Ballast Resistors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
110
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
35
Ignition Wires and Spark Plugs . . . . . . . . . . . . . . . . . . . . . .
111
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
37
Coils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
112
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
39
Starters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
113
Big Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
42
Voltage Regulators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
113
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
42
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
114
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
42
Alternators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
114
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
42
Automatic Transmission . . . . . . . . . . . . . . . . . . . . . . . . . .
116
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
43
Flex Plates and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . .
116
Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .
43
Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . .
116
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
44
Automatic Transmission Components . . . . . . . . . . . . . . . . .
116
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
50
Transmission Overhaul Kits . . . . . . . . . . . . . . . . . . . . . . . . .
118
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
51
Transmission Pans and Hardware . . . . . . . . . . . . . . . . . . . .
119
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
53
P. | 4
818286141.021.png 818286141.022.png
TABLE OF CONTENTS
Torque Converters and Hardware . . . . . . . . . . . . . . . . . . . .
119
Transmission Components . . . . . . . . . . . . . . . . . . . . . . . . .
168
Suspension Upgrades and Components . . . . . . . . . . . . . . .
169
Manual Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . .
122
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
170
Flywheels and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . .
122
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
171
Bell Housing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
123
GTS-R Engine Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
171
Clutch Discs, Pressure Plates and Hardware . . . . . . . . . . .
123
Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .
173
Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . .
125
Eight-Cylinder Late Model Vehicles . . . . . . . . . . . . . . . . .
176
Drivetrain and Rear Axle Components . . . . . . . . . . . . . .
128
Electronic Control Modules . . . . . . . . . . . . . . . . . . . . . . . . .
176
Universal Joint and Yoke Kits . . . . . . . . . . . . . . . . . . . . . . .
128
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
176
Rear Axle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . .
129
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
177
Differential Components . . . . . . . . . . . . . . . . . . . . . . . . . . .
130
Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .
179
Steering, Suspension, and Brakes . . . . . . . . . . . . . . . . . .
132
Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
180
Suspension Upgrades and Components . . . . . . . . . . . . . . .
180
Leaf Springs and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
132
Drivetrain and Rear Axle Components . . . . . . . . . . . . . . . .
181
Frame Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
135
Four- and Six-Cylinder Late Model Vehicles . . . . . . . . . .
184
Torsion Bars and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
135
Suspension Seals and Bushings . . . . . . . . . . . . . . . . . . . . .
135
Turbo Service Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
184
Manual Steering Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
136
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
185
Shocks and Struts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
136
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
186
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
136
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
186
Interior/Body . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
140
Engine Struts and Mounts . . . . . . . . . . . . . . . . . . . . . . . . . .
186
Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .
186
Underhood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
140
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
187
Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
145
Valve Train Hardware and Components . . . . . . . . . . . . . . .
187
Grilles and Headlamp Bezels . . . . . . . . . . . . . . . . . . . . . . . .
147
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
188
Hoods and Hood Components . . . . . . . . . . . . . . . . . . . . . .
148
Suspension Upgrades and Components . . . . . . . . . . . . . . .
188
Handles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
149
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
192
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
150
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
194
Trunk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
151
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
195
Racks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
151
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
196
Bumpers/ Bumperettes . . . . . . . . . . . . . . . . . . . . . . . . . . . .
151
Transaxle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . .
197
Lamps and Lenses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
151
Wheel Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
197
Sheetmetal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
153
Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .
198
Wheelhouse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
154
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
198
Valence . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
154
Bearing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
198
Emblems and Decals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
155
Wheel Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
158
RACING . . . . . . . . . . . . . . . . . . . . . . . . . . . .
202
CHRYSLER/DODGE . . . . . . . . . . . . . . . . . .
164
Drag Racing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
202
Viper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
164
LC22R Challenger Drag Pak Service Parts . . . . . . . . . . . . .
202
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
203
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
164
Gear Drives and Service Parts . . . . . . . . . . . . . . . . . . . . . .
207
Viper SRT10 Power Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . .
164
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
207
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
165
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
207
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
165
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
208
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
166
Hemi Pro Stock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
208
Differential Components . . . . . . . . . . . . . . . . . . . . . . . . . . .
167
Race Bodies . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
208
P. | 5
818286141.023.png 818286141.024.png

Plik z chomika:

Inne pliki z tego folderu:

Inne foldery tego chomika:

Zgłoś jeśli naruszono regulamin